Opel Astra, Zafira

Since 1998 of release

Repair and car operation

The routine maintenance schedule

The intervals of routine maintenance of the car stipulated in the present Section are calculated on independent performance by the owner of a vehicle of all necessary procedures. Duration of intervals was defined proceeding from the assumption that the car is maintained in a daily mode. Constantly to support a vehicle in peak the forms some of procedures at will of the owner can be carried out slightly more often. Composers of the present Management are assured that receptions of the maximum return from the power unit of the car and its other knots and systems can achieve only under condition of a conscientious attitude of the owner to care of the vehicle. It is not necessary to forget as well about necessity of maintenance of a trade dress of the car on a case of its resale.

At operation of the car in the conditions of strongly dusty district, an intense city cycle (frequent short trips), and also at frequent towage of the trailer, intervals of performance of procedures of routine maintenance should be, whenever possible, are reduced to a minimum.

Servicing of a new vehicle, in order to avoid infringement of factory guarantee certificates, should be made on the firm HUNDRED companies-manufacturers of the car.

Through each 15 000 km of run or once a year (that will come earlier)

• Check level of a brake liquid in tank GTTS (Check of levels of liquids see).
• Models with АТ release on 09.2000: Check level ATF, make reading of diagnostic codes of malfunctions and clearing of memory of the module of management (Check of levels of liquids and an engine Electric equipment see).
• Check components ГУР on presence of signs of development of leaks, check level of a hydraulic liquid of system (Check of levels of liquids see).
• Check a condition of protectors and pressure of a rating of tyres, make rotation of wheels (Check of a condition of tyres and pressure of their rating see, rotation of wheels) *.
• Check level and make replacement of impellent oil and the oil filter (Replacement of impellent oil and the oil filter see) *.
• Check a condition and effort of a tension of a belt of a drive of auxiliary units (Check of a condition and replacement of a belt of a drive of auxiliary units see) *.
• Diesel models: Merge a sediment from the fuel filter (Removal of a sediment from the fuel filter of the diesel engine see).
• Check a condition of all hoses of metal tubes laid in an impellent compartment (Check of a condition and replacement of the hoses located in an impellent compartment see).
• Check components of system of cooling on presence of signs of development of leaks, make measurement of density of a cooling liquid with the help ареометра, clean backlashes between radiator plates (Check of levels of liquids, Check of a condition of components of system of cooling and the Head of System of cooling, heating see).
• Check level of target pressure of the storage battery, grease клеммные connections бескислотным with vaseline, on batteries of served type (a supernumerary complete set) check level and electrolit density in banks, in case of need make gymnastics (Check, service and gymnastics of the storage battery and the Head an engine Electric equipment see).
• Check a condition of rubber working elements of brushes of screen wipers (Check of a condition and replacement of brushes of screen wipers see) *.
• Check a condition of components of a suspension bracket and a steering drive, (Survey of components of a suspension bracket and a steering drive see, check of a condition of protective covers of power shafts) *.
• Check a condition of protective covers of the steering mechanism (Survey of components of a suspension bracket and a steering drive, check of a condition of protective covers of power shafts see) *.
• Check a condition пыльников tips of steering draughts (Survey of components of a suspension bracket and a steering drive, check of a condition of protective covers of power shafts see) *.
• Check a condition пыльников spherical support of a suspension bracket (Survey of components of a suspension bracket and a steering drive, check of a condition of protective covers of power shafts see) *.
• Check a condition of protective covers of SHRUS of power shafts (Survey of components of a suspension bracket and a steering drive, check of a condition of protective covers of power shafts see) *.
• Check a condition колодок and disks of disk brake mechanisms (Check of brake system see) *.
• Check a condition of components of a brake path (Check of brake system and the Head Brake system see) *.
• Check serviceability of functioning of a lay brake, in case of need make adjustment тросового a drive (Check of brake system see).
• Check serviceability of functioning of all onboard consumers of the electric power and a condition of connecting electroconducting (electric equipment Check see).
• Check serviceability of functioning of a horn (electric equipment Check see).
• Check serviceability of functioning of lighting and control devices (electric equipment Check see) *.
• Check serviceability of functioning of washers of a windscreen and lenses of headlights (electric equipment Check see).
• Check a condition of an anticorrosive covering of a body and the car bottom (the Control of a condition of an anticorrosive covering of a body and the car bottom see) *.
• Grease locks, loops and an emphasis of all doors, лючков and a cowl (Greasing of locks, loops and an emphasis see) *.
• At a corresponding complete set make zeroing of the indicator of intervals of routine maintenance (Zeroing of the indicator of intervals of maintenance service see).
• Diesel models of release on 09.2000: Make replacement of a filtering element of an air cleaner (Replacement of a filtering element of an air cleaner — diesel models of release on 09.2000 see) *.
• At a corresponding complete set check compressor K/V on presence of signs of development of leaks (see the Head of System of cooling, heating).
• Check correctness of adjustment of a direction of optical axes of headlights (the Onboard electric equipment see the Head).
• Check components of system of release of the fulfilled gases on presence of signs of development of leaks and mechanical damages (see the Head of the Power supply system and release).
• Check transmission on presence of signs of development of leaks (the Manual transmission or Automatic transmission see the Head).
• Make a retightening of bolts of fastening of wheels with demanded effort.

Through each 30 000 km of run or time in 2 years (that will come earlier)

• Make replacement салонного the filter (Replacement салонного the filter see) *.
• Diesel models of release on 09.2000: Make replacement of the fuel filter (Replacement of the fuel filter - diesel models of release on 09.2000 see) *.
• Check level трансмиссионного oils manual transmission (Check of levels of liquids see).
• Petrol models 2.0 of l with engine Z20LET: Make replacement of spark plugs (Replacement of spark plugs, check of condition ВВ of electroconducting see).

Time in 2 years, without dependence from run size

• Make maintenance check in the fulfilled gases of toxic components (Check of turns of idling and structure of the fulfilled gases see).

• Make updating of level of a brake liquid/liquid of a drive of coupling (Check of levels of liquids see).
• Make replacement of an element of a food of a remote control of the uniform lock (the Operation manual see the Head).

Through each 60 000 km of run or time in 4 years (that will come earlier)

• All petrol models and diesel engines of release with 10.2000: Make replacement of a filtering element of an air cleaner (Replacement of a filtering element of an air cleaner - all petrol models and diesel engines of release with 10.2000 see) *.
• Diesel models of release with 10.2000: Make replacement of the fuel filter (Replacement of the fuel filter - diesel models of release with 10.2000 see) *.
• Petrol models, except equipped with engine Z20LET: Make replacement of spark plugs and, - at a corresponding complete set, — check of condition ВВ of electroconducting (Replacement of spark plugs, check of condition ВВ of electroconducting see).
• Petrol models: Make replacement of the fuel filter (Replacement of the fuel filter — petrol models see) *.
• Petrol models 2.0 of l with engine X20XER: Check a condition газораспределительного a belt, its tension roller and cogwheels of drive ГРМ.
• All models, except equipped with engines Z16SE and Y17DT: Check a condition газораспределительного a belt and its tension roller.
• Models with АТ: Check level ATF, in case of need make corresponding updating (Check of levels of liquids see).

Through each 90 000 km of run or time in 6 years (that will come earlier)

• The models equipped with engines Z14XE, X16XEL/Z16XE and X18XE1 with numbers of the power unit with 02LH4239 on 20М18721: Check a condition газораспределительного a belt, its tension roller and cogwheels of drive ГРМ (the Engine see the Head).

Through each 120 000 km of run or time in 8 years (that will come earlier)

• The petrol models equipped with engines X16SZR and X20XEV: Check a condition газораспределительного a belt, its tension roller and cogwheels of drive ГРМ (the Engine see the Head).
• Other petrol models: Check a condition газораспределительного a belt and its tension roller (the Engine see the Head).

Through each 150 000 km of run or time in 10 years (that will come earlier)

• The diesel models equipped with engines of 1.7 l: Check a condition газораспределительного a belt and its tension roller (the Engine see the Head).
• The diesel models equipped with engines of 1.7 l: Check a condition of a belt of a drive of auxiliary units (the Engine see the Head).
• Diesel models 1.7 of l DOHC: Check installation клапанных backlashes, in case of need make corresponding adjustment (the Engine see the Head).