Opel Astra, Zafira

Since 1998 of release

Repair and car operation



Opel Astra
+ Cars Opel Astra and Zafira
+ The operation manual
+ Routine maintenance
+ The engine
- Systems of cooling, heating
   Specifications
   Antifreeze - the general data
   + System of cooling of the engine
   - Systems of ventilation, salon and air conditioning heating
      Removal and installation дефлекторов air lines
      Removal and installation of resistive assemblage приводного the electromotor of the fan of a heater
      Removal and installation приводного the electromotor of the fan of a heater
      Removal and installation of the control panel by functioning of systems of heating / of ventilation / of an air conditioning
      Removal and installation of the main case of a heater
      Removal and installation of the heat exchanger of a heater
      Removal and installation of the switch of a heater
      Check of serviceability of functioning and service of systems of heating and air conditioning
      Removal and installation of the compressor of a central air of air
      Removal and installation of the evaporator of a central air of air
      Removal and installation of the condenser of a central air of air
      Removal and installation of a receiver-dehumidifier of a central air of air
      Removal and installation of the additional fan
+ The power supply system and release
+ Engine electric equipment
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment



Removal and installation of the condenser of a central air of air

 PERFORMANCE ORDER

  1. Make a discharge of a central air in the conditions of a specialised workshop.
  2. At a corresponding complete set open a cowl and disconnect electroconducting from the electromotor of the additional fan of system of cooling located under a forward bumper.
  3. Turn out bolts and disconnect refrigerator tubes from the condenser and a receiver-dehumidifier. Disconnect electroconducting from the pressure gauge-switch in system.
  4. Turn out bolts of fastening of a receiver-dehumidifier.
  5. Turn out the top bolts of fastening of the condenser to a radiator and remove it from the bottom basic clamps. Remove the condenser in gathering with a receiver-dehumidifier.
  6. In case of need the receiver-dehumidifier can be separated from the condenser.

Installation is made upside-down.

The central air recharge should be made in the conditions of a car-care centre workshop.