Opel Astra, Zafira

Since 1998 of release

Repair and car operation



Opel Astra
+ Cars Opel Astra and Zafira
+ The operation manual
+ Routine maintenance
+ The engine
+ Systems of cooling, heating
+ The power supply system and release
+ Engine electric equipment
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
- Brake system
   Specifications
   System of antiblocking of brakes (ABS) and антипробуксовочная system (TCS) - the general information and codes of malfunctions
   Prorolling of brake system
   Check of a condition and replacement of brake lines and hoses
   Replacement колодок disk brake mechanisms of forward wheels
   Replacement колодок disk brake mechanisms of back wheels
   Replacement of boots of drum-type brake mechanisms of back wheels
   Condition check, removal and installation of a brake disk
   Removal, check of a condition and installation of a brake drum
   Removal, regenerative repair and installation of supports of disk brake mechanisms of forward wheels
   Removal, regenerative repair and installation of supports of disk brake mechanisms of back wheels
   Removal, service and installation of wheel cylinders of drum-type brake mechanisms of back wheels
   Removal and installation of the main brake cylinder
   Removal and installation of a pedal of a foot brake
   Check of serviceability of functioning/tightness, removal and installation of assemblage of the vacuum amplifier of brakes
   Removal, check of serviceability of functioning and installation of the return valve of the vacuum amplifier of brakes
   Removal and installation of the vacuum pump of the servo-driver of the brake amplifier (diesel models)
   Check of serviceability of functioning of the vacuum pump of the servo-driver of the brake amplifier (diesel models)
   Adjustment of a drive of a lay brake
   Removal and installation of the lever of a lay brake
   Removal and installation of cables of a drive of a lay brake
   Removal, installation and adjustment of the gauge-switch of stoplights
   Removal and installation of the gauge-switch of a control lamp of raising of a lay brake
   Removal and installation of components ABS and TCS
   Removal, installation and adjustment of the valve-regulator of pressure in hydraulic contours of brake mechanisms of back wheels
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment



Check of serviceability of functioning of the vacuum pump of the servo-driver of the brake amplifier (diesel models)

For check the vacuum gauge is required.

Check

Check is made by means of the vacuum gauge.

 PERFORMANCE ORDER

  1. Disconnect from the pump a vacuum tube and by means of a suitable piece of a hose attach the vacuum gauge.
  2. Start the engine and allow to it to work on single turns, measure depth of depression created by the pump, - after approximately one minute the device should register the indication of an order of 500 mm hg essentially underestimated result testifies to a pump exit out of operation, - consult at experts of car-care centre.

The faulty pump is not subject to regenerative repair and is replaced in gathering.